Frame Corrosion

Toyota's 2005 to 2010 Tacoma frames rusted through. A class action settlement, approved May 21, 2017, covers frame inspection and free replacement once the rust meets a court-set perforation standard. Toyota agreed to inspect these trucks for 12 years from first sale.

Look for flaking, bubbling, or soft spots along the frame rails and near the rear leaf spring mounts. A weak frame is a safety problem. We inspect the frame, document the damage, and point you to Toyota's inspection program. Schedule a frame check before you tow again. Surface rust is normal on an older truck. Scaling and holes are not.

Delayed Engagement and Harsh Shifts

The 2016 Tacoma with the 2GR V6 and AC60 six-speed automatic can engage late from park to drive and shift hard from first to second. Toyota issued bulletin T-SB-0077-16 for these complaints. Owners also report the transmission hunting for gears at cruising speed.

A software update helped some trucks, yet owners still report occasional hard shifts. We check software versions, inspect the fluid, and road test before we recommend parts. Bring your Tacoma in if it clunks into gear. Dark or burnt fluid points to internal wear, so we check it early.

Vibration Under Deceleration

Toyota bulletins T-SB-0124-20 and T-TT-0578-19 describe a vibration in 2016 to 2023 automatic Tacomas while coasting or braking between 30 and 10 mph. You feel it in the seat, the floor, or the steering wheel.

Several parts can cause a shake like this. We road test the truck, inspect the driveshaft and mounts, and follow Toyota's bulletin steps. Worn driveshaft joints and loose mounts are two suspects. Call us if your Tacoma shakes as you slow down.

Knocking From the 3.5L V6

Toyota bulletin T-SB-0015-21 covers a knocking noise on 2016 to 2023 Tacomas with the 3.5L 2GR-FKS V6. Toyota wrote the same bulletin for the 2020 Sienna.

A knock under load deserves a fast look. We listen with a stethoscope, scan for codes, and first check the oil level and fuel quality. Early diagnosis keeps a small noise from becoming engine damage. Tell us when it happens: cold start, hard acceleration, or steady cruising. Schedule a visit when the knock starts.

Rear Brake Hose Leaks on 4x4 Models

Toyota recalled 2024 to 2025 Tacoma 4x4 trucks under NHTSA recall 25V-058. Mud and dirt can build up inside the rear wheels and damage the rear brake hoses, causing them to leak brake fluid. Dealers replace both hoses free.

A soft pedal, low fluid, or wet spots near the rear wheels signal a leak. Muddy trails raise the risk. We inspect the hoses, check your VIN for the recall, and clean out the wheel wells. Brake fluid leaks do not fix themselves. Call us before you hit the trail.